Littlejohn HVAC Solutions is a licensed HVAC contractor in Randolph County, NC, reaching Liberty in about 30 minutes down NC-49 and Asheboro, Randleman, Archdale and Trinity in 45 minutes to an hour. We repair and replace heat pumps, keep propane dual-fuel systems switching over correctly, and rebuild the crawlspace ductwork under the county's Deep River mill houses.
Your local HVAC contractor for Randolph County, NC
Randolph County stretches from the edge of High Point clear down to the Uwharrie Mountains, and HVAC work here changes with the landscape.
Our closest Randolph calls are in Liberty and around the Toyota battery plant on the Greensboro-Randolph Megasite, about 30 minutes from Burlington down NC-49. Asheboro, Randleman and Ramseur run 45 minutes to an hour, as do Archdale and Trinity on the western side. We schedule by area so those drives don't become long waits, and we'll be straight with you about timing.
Deep River Mill Towns, Foothill Farms and Newer Subdivisions
The Deep River cuts through the middle of the county, and the mills along it built Randleman, Franklinville, Ramseur, Cedar Falls and Worthville in the 1800s. Mill houses in those towns are small, often raised on piers over damp ground, and most had ductwork added long after they were built.
South of Asheboro, toward Seagrove's pottery shops and the Uwharries, homes spread out on rural lots and rely on heat pumps backed by propane or oil. Up north, Archdale, Trinity and the areas along I-74 and US-311 filled in with 1980s through 2000s subdivisions, many still running original or second-generation heat pumps.
Humidity hangs around Randleman Lake and the river bottoms, and crawlspaces in those areas stay wet enough to rust furnace cabinets from the bottom up. In winter, a cold snap hits hard in a rural home whose backup heat doesn't work, because the heat pump alone can't keep pace once temperatures sink into the teens.
Typical Randolph County Calls
In the subdivisions around Archdale and Trinity, a typical call is a heat pump from the late '90s or early 2000s that's lost capacity: long run times, a coil that ices up in winter, a bill that keeps creeping. Our heat pump services weigh a repair against replacement honestly, including whether an old R-22 system is worth recharging.
In mill houses in Franklinville and Ramseur, the problem is usually underneath: ducts crushed against the dirt, disconnected boots, rusted plenums. Our duct replacement work lifts and seals new runs, and ductless heads are an option where there's no room for ducts at all.
Around Liberty and up toward Staley, new homes are going up alongside the megasite. First-year owners do well with a maintenance visit to confirm the charge, airflow and condensate drain were set right from the start.
HVAC by home type in Randolph County
Beyond the mill towns, three home types fill our Randolph County schedule.
Rural homes toward Seagrove and the Uwharries
Heat pump plus wood stove or propane
A wood stove near the thermostat satisfies it quickly while back bedrooms go cold and the heat pump barely runs. We relocate the thermostat or add a remote sensor, and set the blower to circulate stove heat through the ducts so the whole house shares it.
1980s–2000s Archdale and Trinity subdivisions
Heat pump, garage air handler
Garage-mounted air handlers with leaky return panels pull in hot garage air, dust and car exhaust. That strains the coil and affects indoor air. We seal the return plenum and cabinet seams with mastic and check the filter rack fits tightly. Our indoor air quality service covers the rest.
New homes near Liberty and the megasite
New high-efficiency heat pump
Drywall dust and sawdust from construction end up in ducts and blowers during the first months. Filters load up far faster than the label suggests. We suggest checking the filter monthly for the first season and cleaning the blower wheel if the system ran during finish work.
Common HVAC problems in Randolph County homes
What we find most often across Randolph County.
| Problem | Why it happens in Randolph County | What we do |
|---|---|---|
| Back bedrooms cold while the living room feels hot | Wood stoves in rural Randolph County homes fool thermostats mounted nearby. | We relocate the thermostat or add a remote sensor and set fan circulation. |
| Exhaust or gas smell coming through the supply vents | Garage air handlers in Archdale and Trinity subdivisions draw air through leaky return panels. | Jesse seals the return side, checks for carbon monoxide and confirms the cabinet is tight. |
| New system losing airflow within its first few months | Construction dust in new homes near Liberty clogs filters and coats blower wheels. | We replace the filter, clean the blower and check the coil face for dust buildup. |
| Rusted-out air handler base sitting in a damp crawlspace | Humidity around Randleman Lake and the river bottoms corrodes cabinets from underneath. | We inspect the coil, replace the pan and raise the unit on a stand. |
HVAC services in Randolph County, NC
Randolph County work runs from brand-new heat pumps to century-old mill house ducts, with plenty of propane backup and aging R-22 equipment in between. The list below covers most of what Randolph County households call about.
Heat Pump Services
Repair, replacement and tune-ups for the heat pumps that heat and cool most Burlington homes, including defrost, reversing valve and backup heat issues.
Learn moreDuctwork Installation & Repair
Complete duct system installation and replacement for crawlspaces and attics, designed for real airflow so every room gets the air it should.
Learn moreHVAC Maintenance & Tune-Ups
Spring and fall tune-ups that catch weak capacitors, clogged drains and dirty coils before they turn into a breakdown on the hottest or coldest day.
Learn moreFurnace & Heating Repair
Gas and electric furnace repair that traces the ignition sequence step by step, with safety checks on venting and the heat exchanger every time.
Learn moreDuctless Mini-Split Installation
Efficient heating and cooling for additions, garages, bonus rooms, and older homes with no ductwork, sized room by room and installed cleanly.
Learn moreMobile & Manufactured Home HVAC
Packaged units, HUD-approved furnaces, belly-board ducts, and crossover ducts repaired or replaced by a tech who knows how manufactured homes are built.
Learn more
Why Randolph County residents choose Littlejohn HVAC Solutions
Randolph County covers a lot of ground, from new homes near the megasite to mill houses along the Deep River and farms toward the Uwharries. Here's what we bring to each.
Liberty is a short run
Liberty and the new homes going up near the Toyota battery plant are about 30 minutes from Burlington, so first-year system checks and same-day repairs there are easy to fit into the schedule.
Mill-house ducts in Franklinville, Ramseur and Randleman
Small homes on piers over damp ground often have ducts lying in the dirt. We replace and hang new runs, seal them with mastic and add vapor barriers, or suggest ductless heads where there's no room underneath.
Straight answers on R-22 heat pumps
Subdivisions around Archdale and Trinity still hold plenty of R-22 equipment. We show whether a recharge is worth it and put replacement options in a free written estimate, with financing available.
Backup heat that actually works
South of Asheboro, rural homes depend on propane or oil backup once temperatures drop into the teens. We test the handoff before winter, and we answer no-heat emergencies 24/7.
A year of HVAC in Randolph County
Spring
Spring pollen from Randolph County's pine and hardwood forests loads filters and coils fast. Change filters, rinse the outdoor coil, and new homeowners near Liberty should check how much construction dust the first winter's filter caught.
Summer
Heat and humidity build in the river bottoms and garages alike. With an air handler in a hot garage, a failing return seal shows up as rising bills and warmer supply air. Feel the vents and call if they aren't cool.
Fall
Before wood stove season, set your thermostat and fan plan so stove heat reaches every room. Have propane or oil backup tested, and check that the heat pump actually hands off on the first chilly morning.
Winter
Cold snaps into the teens push heat pumps to their limits in rural homes. Keep the outdoor unit clear, watch for ice that won't defrost, and keep a working carbon monoxide alarm near bedrooms if you burn wood or propane.
Towns we serve in Randolph County
Serving Randolph County from Burlington
Littlejohn HVAC Solutions, LLC is a service-area business based in Burlington, NC 27217. We come to you — about 30 minutes to Liberty and 45 minutes to an hour for most of the rest of the county.